Hi Sean, What you need to do to legalize your engine swap is to install all the emission equipment originally designed for your engine for the model year of the donor vehicle, not the year of your Vanagon. In the case of a new engine, you have to identify the engine as a replacement engine for a particular model or they will expect your swap to comply with present year standards. The California rule is simple if you pay attention. Year of engine is the standard. It doesn't matter what car or model you are installing it in. The only time that it would matter is when you have a vehicle which is normally not required to be inspected (such as a diesel or vehicle older than 25 years old). In these situations, most people just don't tell DMV (Dept. of Motor Vehicles) that they performed an engine swap. Not legal at all. But is done all day long. If you want to go the totally legal route, you will be expected to do as follows: 1- Provide receipts for the engine serial numbers. 2- Identify the model year of the "donor vehicle" if you are fudging w/ a new engine, make sure that you engine you are using was available for the "donor vehicle" you are claiming. 3- Bring the vehicle to a C.A.R.B. (California Air resources Board) Referee Station. they do not charge for this service. They will inspect that you have all the proper equipment, perform a sniff test (tailpipe emission), then issue and exemption tag if you pass. 4- If you fail the test, the referee will still issue you an exemption sticker but would stipulate that you make the necessary corrections then get reinspected by a commercial inspection station. 5- Once you've gone through this process, all you have to do during the biennial smog inspection is to point out the sticker to the next inspector. the tag will identify your swap along with required emissions equipment. Tadahhh!!! Don't try to put one over on the referees. Don't tell them that your 2.0 inline-4 came in your 1975 Rabbit. Most of the ones I've dealt with are extremely knowledgeable. And when they don't know the particular motor, they have an extensive research library at their finger tips I think you will find that most of the time, they can give you tips on how to get away with certain things. At least, I had this experience almost everytime I dealt with them. I hope that helps. BenT San Francisco |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.