Date: Tue, 29 Aug 2000 10:53:20 -0400
Reply-To: "Carrington, Tom" <TCarrington@ReliTech.com>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: "Carrington, Tom" <TCarrington@ReliTech.com>
Subject: FW: [Audi-VW-Diesels] Some questions...on a diesel engine in a va
nagon
Content-Type: text/plain; charset="iso-8859-1"
Comments to Nate, not me!
-----Original Message-----
From: Nate Wall [mailto:NWall@envasns.org]
Sent: Friday, August 25, 2000 11:53 AM
To: Audi-VW-Diesels@egroups.com; vanagon@GERRY.VANAGON.COM;
diesel@vwfans.com; sdelasal@yahoo.com
Subject: Re: [Audi-VW-Diesels] Some questions...on a diesel engine in a
vanagon
1. The Full Load Stop screw is turned Clockwise (in) to increase fueling.
Ususlly, 1/8 turn will suffice, and certainly no more that 1/4 turn. Note:
Must remove the stainless steel anti-tamper sleeve that is spot welded to
the screw to allow adjustment in. When I did mine I removed the screw (the
pump body will drain diesel), put it in a vice (don't damage the "O" ring),
and cold chiseled it off. Hint: Count the number of turns it takes to
remove the screw. Then install it the same number of turns for the same
initial setting.
2. ???
3. I guesss somewhere around 50 - 60 h.p. (the Ecodoesel got 58 - 59 and
does not have the boost enrichment diaphram on the pump. Compression
figures for the TD are the same as the NA: 500 new, 410 min? and no more
than 75 psi variance?
4. ???
--Nate
>>> <sdelasal@yahoo.com> 08/24/00 07:44PM >>>
Todays selection of Q's are...
1. Which direction do I turn the pump 'fuelling' screw to adjust max
fuelling - clockwise of anti-cw?
2. Is there an archive for this list that I can search?
3. If I put a TD engine in my vanagon but run it with a non-td fuel &
exhaust system, what power should I expect? Anyone know the compression
figures for the 1.6TD engine - can't find them in my Bentley manual - not
surprising as the engine was never an option in NAmerica.
4. Anyone got any leads on a good NA or TD engine suitable for a vanagon
i.e. known good oil pressure & compression pressure - ideally, not too far
from SE Michigan
Thanks... steve
-------------------------- eGroups Sponsor -------------------------~-~>
GET A NEXTCARD VISA, in 30 seconds! Get rates
of 2.9% Intro or 9.9% Ongoing APR* and no annual fee!
Apply NOW!
http://click.egroups.com/1/7872/10/_/523453/_/967156820/
---------------------------------------------------------------------_->