Jay, Here's how the dual battery system in my Westfalia looks like: Main battery is behind the pass seat. No. 2 AUX is under the rear seat. A 4-way boat battery switch manages them like this: Both supply power thru the main fuse block. No need to run extra wire. When you want to run off #2, switch to #2, and likewise for #1. And you can switch to #ALL, which is where you leave it to charge both batteries (this is best for when both batteries are same size and condition. Since different size and condition batteries charge at different rates, the alternator regulator will taper off the charge sensing the more fully charged battery, leaving the second battery undercharged. In this case you switch to 1# half the time and #2 the other half, so that one battery gets the full alternator output.Wireing up the switch is simple. The pass # 1 batt cable is disconnected from the starter and connected to the #1 terminal of the switch. New cable is connected to the starter and goes to #COMMON on the switch. A shorter cable is attached to #2 on the switch. Second battery is grounded at a seat belt mounting point. In my set up, the switch sits on top of the rear seat heater box. Having a switch within reach while driving is not a good idea, since switching while the engine is running will ruin the alternator. Isolators waste a volt, and have trouble sensing 2 batteries at a time. The other advantage of this set up is the cables used are battery size, a turn of the switch and the good battery will start your motor-you will almost never need a jump start again. A good switch is the Guest 4-way for $23.99 at West Marine (www.westmarine.com) Happy New Year! Robert
Robert Keezer
1982 Westfalia 1983.5 Sunroof Vanagon 1980 Westfalia
[text/html]
|
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.