John's explanation sounds good, but you should also realize that running the engine for a few minutes will not move coolant from the overflow tank into the expansion tank, a complete warming -cooling cycle is needed. If there is too much air in the expansion tank, it will not be driven out until the coolant expands as the engine reaches full operating temp. Then when the engine cools down, the contraction of the coolant in the system will draw fresh coolant from the overflow tank, thru the valve in the pressure cap and into the expansion tank. If you don't want to wait, you can disconnect the hose from the pressure cap, remove the cap, and top it up yourself. Be careful about opening the pressure cap when the engine is hot. Larry Alofs '91 GL "Vinnie"
dianne gigler wrote: I started the engine > and let it run for several minutes to see if the level in the reserve tank > went down. It did not, so I closed things up and drove away. > > About three minutes later, the light came on again and the needle was below > the half-way mark. I checked the reserve tank level and it was still at > the "max" level. Against my better judgement, I decided to proceed to my > destination which was about seven miles away. The light remained on the > entire time, but once again the needle did not go beyond the half-way mark. > I made arrangements to borrow car and garaged the vanagon at my destination > after once again checking the coolant level which had not change. |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.