Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (February 2001, week 1)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Mon, 5 Feb 2001 13:16:24 -0700
Reply-To:     Mark Keller <tyler@ISLANDNET.COM>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         Mark Keller <tyler@ISLANDNET.COM>
Subject:      Re: Rapid Idle when Warm / Throttle idle switch
Content-Type: text/plain; charset=us-ascii

The idle stabilization system is really to improve cold engine driveability off idle. A warm engine should idle at the 880 RPM with the idle air motor disconnected. Even though the system is always active, the base engine idle adjustment should be with the normal range with it disconnected.

The base engine idle speed is set with the engine warm and the idle system disabled. Idle speed is then manual adjusted by turning the air bypass screw in or out. It wouldn't hurt to disconnect the O2 while doing this and monitoring it. The CO adjustment is done after the idle is correct. Simply turn the allen screw beneath the cover located on the AFM .

I target .5 volts. on the O2 at idle What your really adjusting is the air vane position at idle. Give it a try.

Then connect the idle stabilization system and see how it behaves on cold start.

Sincerely,

Mark Keller 91 Carat


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.