Dave Kitzmann <kitzmann@EXIS.NET> wrote:
>I have my exhaust routed forward >at first on my conversion. It leaves the >engine bay on the driver's side >goes forward past the frame member comes >into a large first muffler then turns >back toward the passenger's side and >comes to a second muffler under the >small cavity behind the wheel. I did similar, the downpipe leaves the engine bay in front of the gearbox and enters first muffler. There is a 180 degree turn back just behind the fuel tank and the exhaust pipe enters second muffler. After a S elbow there is the third muffler beside the engine on passenger side. This is a very quite setup, too. You may find pictures about the system at my web site http://volksweb.relitech.com/helmut But: The two mufflers below the center floor heats up the passenger room, not that nice during hot summer time. It keeps your feet warm during winter :-) At present one cylinder on the I5 burns oil and therefore the exhaust noise is increased significantly. For the rear passenger it's getting very noisy on high engine loads, but still it isn't too noisy. In future I would route all exhaust related pipes and mufflers somewhere inside engine compartment, even the temperature will get very high for the engine. Some airflow should be added. Maybe cutting out the license plate and replacing it by a grill. Helmut '80 Vanagaudi |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.