At 01:21 PM 4/19/2001, Marcus Ward wrote: >1. I am considering replacing my fuel tank sender unit because the fuel >gauge is reading low. I have replaced the voltage regulator and tested it. Meaning, you measured it at ten volts +/- half a volt? >I have grounded the fuel gauge and it reads full quite quickly when I do so. >Sender is left? How sluggish is the fuel gauge normally? The gauge takes maybe a minute to reach a final reading, might be more at very low readings. Also may need to be tapped or vibrated to come to final reading (the engine usually takes care of that) -- oil on the pivot may be useful, don't know. You have to remove the gauge completely to get to that. The test box mentioned in Bentley is *not* calibrated in ohms but in some arbitrary VW unit. I've measured one gauge that AFAIK works reasonably -- at ten volts, it takes 250 ohms for bottom of the red, 150 for top of the red, 110 for one quarter, 75 for one half, 40 for full. You could make up test resistors of 250 and 40 ohms to see how that corresponds to yours. The specified limit in Bentley is +/- one needle width at both top and bottom -- I suspect that they're typically closer than that but don't know for sure. Changing the input voltage to 10.5 or 9.5 moves the needle about one needle width at full scale and somewhat less at top of the red. Grounding the gauge for any length of time will produce an overheated smell and will probably change the characteristics of the gauge somewhat. david
David Beierl - Providence, RI http://pws.prserv.net/synergy/Vanagon/ '84 Westy "Dutiful Passage" '85 GL "Poor Relation" |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.