Mark & Laura Magee wrote: > Volks, > A dash buzzer went off me the other day intermittently and I had never > heard it before and didn't know what it was signaling. I later in the > drive (almost home) notice that when the buzzer buzzed, the oil light > flickered. I discussed this with my wife, to keep a sharp eye on this > situation. I jumped in my other sled and went to work, wife called later > and buzzer scared her, she pulled over and oil had been lost, about 1 > quart. > I traced the oil leak to the oil pressure sending unit located near the > oil pump. I talked to my mech and between his opinion and my own > experience I replaced the sending unit. This fixed the oil leak, but now > the buzzer -still- goes off after about 10 minutes of driving and the > oil lights on. > My mech tells me their were apparently problems with this IC board that > contains this buzzer unit, and it is prone to failure. > There are no other symptoms. Car no longer leaks and runs great, but > buzzer buzzes and oil light flickers after about 10 mins driving. > I am lost at explaining how the sending could fail (leak oil) and that > simultaneously the IC board could fail that sets off the buzzer and oil > light. I suppose it it possible that this first "buzz" on the buzzer > fried some component on the board. > Nonetheless, anyone have this happen to them. I think my mech will > recommend disconnecting the buzzer (if I can get to it!), as he said he > has done in quite a few VW's due to defective IC board/components. > Anyone have any ideas? Should I disconnect the buzzer unit? Will this > disable the idiot light function. > I will probably install a gauge in the future, but for know I can't > drive to unnerving feature of buzzer scaring wife into thinking she is > cooking the engine. > Any and all help/feedback appreciated. > Mark Magee > 90 Vanagon Carat It seems likely that you have installed the 1.8 bar switch ( 056919081E ) when you should have the .9 bar switch ( 068919081A ). It seems that dealers routinely give us the wrong one. BTDT Larry A. 91 GL |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.