At 07:35 PM 12/20/2001, The Bus Depot wrote: >is some risk associated with doing so. Say you used a relay/wiring of >infinate capacity (it would pass as much current as the aux battery wanted >it to). If the aux battery were totally dead or shorted, as soon as you >turned on the ignition, it would try to pull everything from the starting >battery all at once, and the relay would let it. The result of that sudden >massive current transfer could be a fire or explosion. No, it is not a huge >risk, but it is a real one, just as there is that potential when you try to It's really not that simple, Ron. Batteries are active (sort of) devices and don't behave like simple resistive loads. If the aux battery really was completely shorted your "15-amp" 12-ga setup would pass something like one thousand amps until something melted, so that issue is moot ISTM. Any paralleling system should no doubt be fused in keeping with its capacity -- however even the stock setup has high-capacity wiring running to starter, alternator, relay/fuse panel -- and not a fusible link in the bunch, so to a certain extent it's the pot calling the kettle black. Even back in '84 the Japanese were putting fusible links (hi-amp fuses really) on everything in the harness except the actual starter wire. And incidentally the factory aux battery wiring was 6.0 mm^2, slightly larger than 10 AWG -- the same size they ran from the battery to the fuse/relay panel, rated by DIN to carry 54 amps at 30C and 38 amps at 50C. A good deal heftier than the kit you sell, I believe. david
-- David Beierl - Providence, RI http://pws.prserv.net/synergy/Vanagon/ '84 Westy "Dutiful Passage" '85 GL "Poor Relation" |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.