Well after delaying the inevitable for about a year, I finally have come down to replacing the long plastic coolant pipes in my '91 Carat Vanagon. Some background: As long as I have owned the van I had some coolant usage. I could never find a leak, but the level would go down very slowly over a period of months. I resealed the heads and this seemed to slow it down even more, but it would still use some. Then I was going to a VW show and the red blinking light came on. Coolant was pouring out of the front of the van near the spare tire carrier. The plastic pipes have a metal piece bonded into the end, and this had separated from the pipe on that end. At the time I was on the road so I just pushed the metal piece back up inside the pipe as far as it would go and clamped the tar out of it with a new clamp. It stopped leaking or using coolant until about a few weeks ago. Now the clamp will no longer hold and pipe replacement is required. I got my new pipes at the dealer for around $250 for the pair(ouch). An interesting note is that my original pipes say "West Germany" on them and the new ones say "RSA" (yup South Africa!). They seem to be made out of the same material which I believe is PVC. I just had the gas tank filled and wanted to at least attempt pulling these without taking down the gas tank (hey it was worth a shot). It took some work reaching on top of the gas tank to cut all of the 55 tie wraps that VW put on these pipes (someone's brother must own a tie wrap factory!). Unhooking the pipes and trying to direct the coolant flow into a container was a fun challenge. I got a coolant bath for my troubles, but it almost felt good today in the heat :) I was able to pull them out from the top of the tank without dropping it. I just used a pair of ramps in the front. It would be way easier (and probably neater) if you had a lift. I am currently inside drying off. After lunch I'll go back out and see if I can put them back without dropping the tank. I'll try to post the conclusion then.
Thanks, Ken Wilford John 3:16 http://www.vanagain.com Phone: (856)-327-4936 Fax: (856)-327-2242 |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.