Date: Fri, 20 Sep 2002 13:06:48 -0700
Reply-To: kevin obrien <kevindobrien@YAHOO.COM>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: kevin obrien <kevindobrien@YAHOO.COM>
Subject: Infrared Thermometer Readings....analysis & feedback requested
Content-Type: text/plain; charset=us-ascii
Hello All:
Awhile back I bought an Infrared Thermometer in an
attempt to evaluate my 1990 Carats (2.1L) overheating
(getting hot) on long uphill stretches. Several of you
suggested where to take readings...so here they are.
Please send feedback accordingly...any and all
appreciated.
Van is parked with the nose slightly uphill. I let her
idle until the radiator fan kicked on.
I put the heat on full and took readings...
I’ll refer to left and right FACING the engine (toward
front of Van)
All measurements in Fahrenheit
Thermostat housing itself: 176?
2 hoses running from above into Thermostat (ones
attached to the white plastic hose that circles the
engine compartment):
Left 155? Right 176?
Big Hose on right side of Thermostat : 178?
Big Hose on left side of thermostat: 176?
Hose coming toward me out of thermostat: 182?
Right Head (measured under van -just behind Valve
covers): 203?
Left Head: (measured under van - just behind Valve
covers ) 205?
Waterpump: @ 185? (tough to reach)
Radiator: (R&L Facing the radiator)
Right side: 170?
Left Side (with bleed valve at top) 163? near bottom
...134? at top -just below bleeder screw. NOTE: I
checked this several times...there was always about 30
degree difference from the top and bottom of this side
of the radiator. WHY?
Front of radiator (random readings around the grid)
89? to 92?
Expansion Tank: Hose coming in to top of tank: 171?
Hose coming out the bottom 176.5?
Someone asked me awhile back if the radiator fan blew
out or suck in....I held a piece of paper to it...it
sucked the paper toward the radiator when the fan was
blowing.
Anybody see anything odd??? Anything I missed...or
suggestions for additional readings?
Note: I took a measurement from my temple as I stared
at the perpetually blinking coolant light...and the
thermometer went off the chart!!! :-)
Thanks in advance for any suggestions.....
kevindobrien@yahoo.com
__________________________________________________
Do you Yahoo!?
New DSL Internet Access from SBC & Yahoo!
http://sbc.yahoo.com