I put an S&S Header ( http://www.ssheaders.com or list vendors) system on my '87 Vanagon (different from your exhaust) when it was time to replace the whole thing. I wrote this up a year or two ago, so you can probably search for it in the archives. In a nutshell, it's a cheaper alternative to the factory exhaust and it appears to be a bit freer flowing than the stock. My seat-of-the- pants dynamometer told me we had a bit more power than before the change and I head less trouble staying in 4th gear on hills. As far as quality, it's not as thick as the stock exhaust and you can expect that it won't last as long. Then again, it's cheap, and I figure I can slap on another one for <$300. You need to reuse your existing cat, so don't trash that. Aside from the environmental effect, you need a spot for your O2 sensor, not to mention that the brackets on the S&S won't bolt up right if you don't have the cat (or similar length spacer) installed. List vendors have cats for $100 or so. While others had reported problems with the slip fits on the exhaust, I had no such problems. I did have to "encourage" one of the slips fits with a rubber mallet, but it was no big deal. A minor note: if you have a tow-hook mounted trailer hitch, the S&S tailpipe will interfere and you'll need to hack about 1-2" off the end of the tail pipe. Again, no big deal. If you're going for the long haul, you may want to consider a longer lasting original exhaust (available at a discount over dealer prices at list vendors, e.g. BusDepot) and/or the Stebro stainless exhausts. I have no experience with these, so YMMV. -Karl Karl & Kristina Bloss - Hurricane, WV '85 Westfalia Camper "Fred" '93 Eurovan MV "Amelie" WV VW Club: http://WVVW.ORG "Bound to cover just a little more ground..." |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.