Date: Mon, 25 Nov 2002 22:59:02 -0800
Reply-To: David Marshall <vanagon@VOLKSWAGEN.ORG>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: David Marshall <vanagon@VOLKSWAGEN.ORG>
Subject: Re: glad to meet you
In-Reply-To: <OE38yfogkJXrRjbDt3H0000019a@hotmail.com>
Content-Type: text/plain; charset="iso-8859-1"
This sounds like the same problem that stumped me this spring when I was
installing a Digifant II 2.0L just like what you have. I machined down the
intake manifold so I wouldn't have to pound as big of a dent in the side
wall. Anyhow - as one machines down the intake manifold the intake runners
move with respect to the bolts that held it in place. To make a long story
short is was an air leak in my intake system that caused it to do this. It
would buck, snort, back fire (LOTS of fire). To figure out where the leak
was coming from I removed the AFM and stuck in a plastic ABS end with an
adapter for my air compressor - I set it to about 20 PSI and set the motor
to TDC and then listened for the hiss - sure enough it was leaking around
the intake manifold gasket. It was VERY frustrating - several AFMs, 3 ECUs
a lot of stuff went into this in the end simple problem. Don't give up on
the Digifant II system - it does work quite well!
David Marshall
Fast Forward Automotive Inc.
4356 Quesnel Hixon Road
Quesnel BC Canada V2J 6Z3
http://www.fastforward.ca mailto:sales@fastforward.ca
Phone: (250) 992 7775 FAX: (250) 992 1160
- Vanagon Accessories and Engine Conversions
- Vanagon, Transporter and Iltis Sales and Importation
- European Lighting for most Volkswagen models
-----Original Message-----
From: Vanagon Mailing List [mailto:vanagon@gerry.vanagon.com]On Behalf
Of Robert Keezer
Sent: November 25, 2002 7:25 PM
To: vanagon@GERRY.VANAGON.COM
Subject: glad to meet you
.bat! .exe! .com! .cutting out! Dot SHocked? Jolted? Lurched? Dot fooled?
Sorry to fool you, but so my engine has been fooling me!
SO I resort to deceptive measures hoping to jolt the answer out of a list
experts mind! There are list experts, aren't there?
I have searched everything on my engine. It's a SEARCH ENGINE! I searched
for the problem-I'm still searching!
A few days ago I posted my Vanagon engine ( 2.0 '95 Golf /Digifant ll) was
cutting out.
After four days of troubleshooting(that's four full days), I threw up my
hands and asked the list. I took your advice and thought I found the
reason -a bad ECU. I e-mailed the list to say thanks and went on a 250 mile
trip.
At the 200 mile mark the engine stalled on the freeway. The cutting out is
back with a vengeance.
The way to deal with it while on the trip is to turn off the ignition, then
back on and let out the clutch.
Now it lurches every two seconds. I'm about to throw my hands out and empty
my wallet at a repair shop.
SO far I have only been able to throw parts at the problem. Everything
checks out ok. The air flow meter has been swapped to three other good
working ones. But the symptoms seem to be AFM related.
What else can cause these symptoms? Just as you start out in first, the
engines dies, then starts, then dies, like every 2 seconds. If you try to
floor it, then the lurching becomes violent to the point you think the
engine will rip loose from it's mounts.
The nature of this is that i can start it up after sending this message, and
it might run fine around the block or down the freeway 10 miles before it
starts cutting out.
Then it will go away after i restart the engine . The cutting out comes and
goes at random without any definite pattern. It's unprdictable.
I have had four years of reliability and one week of trouble so this is not
a reason to change over to Motronic, or is it?
Can the Hall sender cause this? I need some more ideas!
I'm going out now to check the idle and full throttle switch. Digifant ll
is similar to Vanagon Digifant with the exception of an idle stabilazation
control relay .
Digifant ll incorporates all control functions in one box.
The components : are ECU, Cool temp sensor, AFM, Idle stabilizer, O2 Sensor,
idle /full throttle switches, Hall control, Hall sender, Fuel pump, pressure
regulator, and injectors.
Any suggestions ?Or should I take these questions to a Golf-Jetta list?
Robert
1982 WestfaliaGet more from the Web. FREE MSN Explorer download :
http://explorer.msn.com