In a message dated 1/9/03 12:28:03 AM, openwhel@BELLSOUTH.NET writes: << I would add to your list of "Before alignment steps": Check tire pressure, road check, then....... Center the steering rack, before centering the tie rod ends. There is an alignment "slot" on the shaft as it comes out of the rack, align it with the raised "boss" on the rack, then center the steering wheel (if needed), and lock it down, then base adjust your tie rod ends. Adjust camber, and finally set the toe. >> Howard, The Devil is in the details. Thanks for the proper procedure. I haven't paid much attention lately, do alignment shops still weight the driver's seat? Some time ago, I swapped a manual rack into a 240 Volvo. I cranked in some toe-in just so that I could use it for a couple of days until the alignment shop could take it. During the wait, I had to parallel park in a really tight space. I wasn't sure I could fit it in, but I always felt that parking a car in a tight spot was some kind of measure of my driving skill, if not my machismo. When I cut it in, it almost slid in sideways because the steering was so far from centered. Now, there were two guys in a pickup behind me and they were aptly impressed with my parking. As they went past, the passenger called to me,"Wow! Those Volvo's can really cut an angle!" Here's the kicker: A few weeks later I was in a bar swapping lies with a buddy and telling him about the Volvo I had just redone. A guy downstream from us got wind of our conversation and asked me if those 240's can really turn on a dime like everyone says. Oh yes, the power of the urban legend. George |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.