At 09:58 AM 5/19/2003, Tonya Pope wrote: >attached to a dangling horn mechanism, they get close to 12V >(probably a matter of me not attaching the leads as good on the >meter) and sounds like a sick duck, but works. When I put it in >place and tighten the nut holding it on, I only get about 6V across >and all you hear is a thunk. The thunk is the noise of the diaphragm being moved, but not enough to break the internal contact... Use your meter and find out where the other 6v is being dropped -- you've got a poor connection somewhere. The wiring is very marginal anyway, you'll get improvement by using the horn switch to drive a relay instead of the horn directly; but this isn't marginal, it's broken. Use B+ and B- (at the battery) as your reference points for measuring and follow the voltages around. Ideally you'd get no drop at all until you get to the horn, then the entire voltage dropped across the horn -- in practice you'd expect to lose possibly as much as a volt in the wires. Because the horn is a rapidly interrupted load it will generate lots of noise on the wiring (not to mention your ears) when it's working -- if this makes it hard to measure substitute a static load for the horn: old headlight would be ideal, but one or two stop-light bulbs in parallel should give enough load to get useful voltage drops. Come to think, your problem is bad enough that wherever the bad connection is will probably get pretty hot if you use any serious load and operate it for more than a second or two -- better to use say a single tail-light (not stop-light) bulb and see if that gives you enough load to follow the drops around. Otherwise the smoke may locate the problem before the meter does. david -- David Beierl - Providence RI USA -- http://pws.prserv.net/synergy/Vanagon/ '84 Westy "Dutiful Passage" '85 GL "Poor Relation" |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.