Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (November 2003, week 3)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Wed, 19 Nov 2003 13:41:24 -0800
Reply-To:     mark drillock <drillock@EARTHLINK.NET>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         mark drillock <drillock@EARTHLINK.NET>
Subject:      Re: horsepower increase TANSTAAFL
Comments: To: David Brodbeck <gull@GULL.US>
Content-Type: text/plain; charset=us-ascii

This is not quite right. The complete 1.9TD has the turbo mounted high enough even when the engine is leaned over at the Vanagon position. The oil return line enters the block well above the oil pan. The turbo height controversy, such as it is, applies to turbos mounted with the factory Vanagon TD manifold which mounts the turbo lower and returns oil to the pan at a shallow angle. 1.9TD motors using a 1.9TD turbo and manifold are not this way. Personally I doubt that there is much of a problem with the oil return arrangement that VW used on a half million TD Vanagons. Perhaps if the turbo seals are worn and/or there is much blowby in the engine then the mounting position may make a difference.

Mark

David Brodbeck wrote: > > You *can* install a 1.9TD without raising the deck lid. Most people > prefer not to do it that way, though. I've heard there are lubrication > issues because the turbo ends up so low compared to the oil pan. > > Personally, I think when it's time to re-engine my Westy I'll go for a > 1.9L normally-aspirated diesel. But that certainly won't make it faster > than a wasserboxer. ;) > > David Brodbeck, N8SRE > '82 Diesel Westfalia > '94 Honda Civic Si -- For Sale > '86 Volvo 240DL wagon


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.