At 02:10 PM 12/4/2003, you wrote: >I was looking at a way to hook the aux and vehicle batteries of the Westy >together. I have a charger set up on the aux batt, so that it gets charged >whenever the vehicle is plugged in. I would like to connect the two so >that the vehicle batt can share in that charging when needed. Or let the >aux batt boost the vehicle batt when needed. So I thought, there's already >a relay in place to do this. How about a little switch to energize the >coil on that relay? I tried applying 12V to the blue wire and that did the >trick. So then I started to find a switch to install for the purpose. Now >I am thinking about where that 12V is going to go when it also travels back >down the blue wire to the alternator. Is this a bad idea? Thanks for any >input. > >Edward Use a single pole, double throw switch (SPDT). Disconnect the blue wire from the relay and connect it to one of the switch terminals (not the common). Connect the relay terminal (where you removed the blue wire) to the switch "common" terminal. Connect the remaining switch terminal to a source of +12v. One switch position is for charging, the other for "normal" running, with no interaction between the two. Use a 3 position "center off" switch if you like to also add a "relay is always off" mode. BUT... Marks comments about safety and wire size are very valid ones The relay should NEVER be energized during starting or severe nastiness could occur. At least put a fuse in the wire between batteries just in case... Steve EJ22 -> '86 Westy "Escape Pod" |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.