In a message dated 2/2/04 7:50:29 PM, dhaynes@OPTONLINE.NET writes: << Brake squealing is not actually caused by the pads and rotor rubbing but the movement of the pads in the caliper housing or in the case of drum brakes, the shoe rubbing on the backing plate. Better brake pads will now often have a silencer shim built in. If not, replace it. Also, brake silencing goo will help applied to the back of the outer pad. Hi temp. caliper grease should be used where the pad backing plate sits in the carrier. >> Regarding disc brakes: While it is possible for a caliper to be misaligned because of poor repair work, damage or as the result of faulty manufacturing, which can cause the brakes to squeal until enough pressure is applied to force the caliper into alignment, a frequent cause of brake squeal is that the rotor is not being clamped by equal but opposite forces on both of its faces. If the brake system has been neglected, the simple act of retracting the caliper pistons to install fresh pads can cause a piston to bind to one degree or another. Whenever the pistons are retracted for pad replacement, they are forced into a portion of the caliper bore which has become a reservoir for all the crap in the old brake fluid. Whatever is in there can interfere with the sure and smooth movement of the piston. Applying "brake silencing goo" is at best a Band-Aid which only dampens the vibration and might mask a serious mechanical defect. I once had a 70 mph get-off right after a mechanic thought that, instead of changing out the caliper, "goo" was the cure for the squealing brakes of my new bike. Once the dealership paid my attorney's tab with a little left over for me, they saw the light. Grease should never be applied to the pad seats of the caliper; just clean the seats thoroughly. George |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.