Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (May 2004, week 2)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Sun, 9 May 2004 16:17:59 +0200
Reply-To:     Calle Fallberg <calle.fallberg@TELIA.COM>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         Calle Fallberg <calle.fallberg@TELIA.COM>
Subject:      Re: Coolant coughing up?
Content-Type: text/plain; charset="iso-8859-1"

Ok, It might be a headleak BUT Iīd try not to worry ībout that right away ! You wrote that youīd just replaced the waterpump, whatīs the reason for doing so, was the Vanagon coughing water before that ?? If not the problem you have is most likely to be caused by air ! There are these looooong hoses and pipes, radiator away from the engine and big chance that you have an airbubble somewhere ! Additional heater under the back seat ? Another place to get air ! I havenīt got the Haynes so I donīt know how the procedure is described but according to the Haynes manual you raise the front at least 15 " over the rear , full heat on every heater and bleed the radiator - for a long time, not just a few drops , and the best is if the engine is really hot when you start ( donīt get burnt !) Iīve tried this and it worked for me - even after changing to the Volvo engine..... And if this doesnīt help, look for cracks in the expansion container or leaks from the lid ! BTW - did you replace the thermostat ? Many times remaining air in the system is caused by the fact that there are airbubbles under the thermostat, preventing water to get up and heat - open the thermostat ! You check this by squeezing or feeling the hoses leading to the thermostat housing once the engine is hot , you should be able to sesnce the heat or at least water running inside . There might also be a bleeding valve on top of the housing........

Start with this and if it doesnīt help weīll go on from there...

Good Luck Calle -88 Volgon Mullhyttan, Sweden

> -----Original Message----- > From: Vanagon Mailing List [mailto:vanagon@gerry.vanagon.com] On Behalf > Of Jim Shinosky > Sent: Sunday, May 09, 2004 1:40 AM > To: vanagon@GERRY.VANAGON.COM > Subject: Coolant coughing up? > > Hi y'all I am back. My '88 Weekender start coughing up its coolants > after > its warmup and engine turn off... I recently replaced its waterpump. I > tried the > radiator bleeding method from the manual and it s still coughing up the > coolant. I tried filling up the cold radiator and bleeding the entire > system. But > it still coughs up the coolant... What is the real problem? and remedy? > Thanks > in advance for any help or tip... > > Jim > W88kender > Los Angeles >


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.