Hi Shannon, I think you have a cliassic case of corroded Vanagon ground strap connection syndrome <g>. There are two straps that need checking, and it is best to remove them both, clean them and re-fit them. I am 90% sure this action will solve your problem. The first strap is from your battery's negative (-) terminal to the body. Remove the bolt securing the strap to the body (13mm wrench). Clean the terminal (the fitting at the end of the strap) with a file or a coarse abrasive paper. Clean any corrosion (rust) from the area of bodywork that the strap attaches to. Clean any corrosion from the bolt, or replace it with a new one. A new washer would be good, too. Finally, coat the end of the strap and surrounding bodywork with petroleum jelly (Vaseline) to prevent further corrosion. Re-fit the strap, bolt and washer. Try starting the engine. If it works fine, you may not need to follow the next part of my reply. If the starter is still slow, the likely culprit is the ground strap at the front of the gearbox. For the avoidance of doubt, this is at the end of the gearbox nearest the front of the vehicle. It resembles your battery ground strap except that both ends accept bolts. Remove the strap. This involves getting right under the centre of your Vanagon, so make sure the parking brake is on and that you have selected first or reverse gear (manual shift transmission) or park (auto transmission). Clean any corroison from the terminals and the mating surfaces on the bodywork (main chassis rail) and gearbox. Clean or preferably replace the bolts and washers. Refit the strap. Coat ends and surrounding areas with Vaseline or copper-based grease. Job done. Your Vanagon's engine should now spin rapidly when you operate the starter. I have heard it said that 90% of Vanagon starter motor problems can be cured this way. Good luck! Tony
>From: "Shannon Mitchell" <vanagonman@EARTHLINK.NET> >To: <vanagon@GERRY.VANAGON.COM> >Sent: Sunday, May 30, 2004 11:52 AM >Subject: 91 Vanagon will not start..? > > > > I have a 91 Vanagon that I can't seem to get to start with out jumping >it.. > > I went out and got a new battery and the battery and the same thing > > happened.. so I took the battery back and they gave me another one and >still > > nothing.. the battery tests fine.. when I turn the key it acts like >there >is > > a dead battery but there isn't.. it turns over REAL SLOW and nothing.. >but > > if I jump it with another vehicle she will start right up.. > > > > Any thoughts? > > > > Thanks in Advance.. > > > > Shannon > > 91 Vanagon |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.