Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (June 2004, week 2)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Fri, 11 Jun 2004 20:16:41 -0500
Reply-To:     Stan Wilder <wilden1-1@SBCGLOBAL.NET>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         Stan Wilder <wilden1-1@SBCGLOBAL.NET>
Subject:      Re: vanagon Digest - 11 Jun 2004 - Special issue (#2004-549)
Comments: To: Mark Tuovinen <mst@AK.NET>
Content-Type: text/plain; charset="iso-8859-1"

Indexing spark plugs is Snake Oil. The spark remains in the center of the plug, well close enough. I'd like to see some test that show appreciable change in performance on anything other than a 1 cylinder fractional horsepower engine.

Stan Wilder

----- Original Message ----- From: "Mark Tuovinen" <mst@AK.NET> To: <vanagon@GERRY.VANAGON.COM> Sent: Friday, June 11, 2004 7:50 PM Subject: Re: vanagon Digest - 11 Jun 2004 - Special issue (#2004-549)

> Don, > > Indexing spark plugs is not about changing the angle of entry. It is done to ensure that the electrodes are aimed to put the spark in the same spot in all cylinders. By having the electrodes aimed correctly in the combustion chamber you will get equal power from each cylinder, so the theory goes anyway, I have never seen data to confirm or deny this, though it does make sense. Because not all spark plugs will have the electrode pointing in the correct direction once they are installed, shims are used to adjust their position. If the plug was a quarter turn off you might add one shim which makes the threaded portion of the plug sit higher in the head and and the electrode stop in the proper position. I have also seen an automobile manufacturer index plugs on cars in an attempt to squeeze extra fuel economy out of them. > > Mark in AK > > ----- Original Message ----- > From: don spence <dspence@OANET.COM> > Date: Friday, June 11, 2004 3:56 pm > Subject: Re: vanagon Digest - 11 Jun 2004 - Special issue (#2004-549) > > > Uh Bruce, no offence but I think you've been taken by an urban myth. > > The angle of the plugs entry into the combustion chamber is controlled > > by the angle of the spark plug hole or port. Any lop-sided shim/washer > > would only effect the seal at the base of the plug. I can't > > imagine a > > washer that could overpower and reorient a plug bore. If you want to > > change the angle you'd have to drill and tap the holes where you want > > them. yes? No? > > On Friday, June 11, 2004, at 03:28 PM, Automatic digest processor > > wrote: > > > > > Any of you hot rodders out there remember the indexing washers for > > > sparkplugs? These were essentially shims that you would use to "aim" > > > your > > > spark plug when installing your plugs in the head. When torqued, if > > > your > > > plug wasn't at the optimum angle (spark not facing the most > > turbulent> fuel/air mixture), you pulled the plug out threw in one > > or two more > > > indexing > > > washers and the angle of the plug could be aimed to optimize > > burn for > > > most > > > power (they weren't worried about emissions in those days, but a > > > better burn > > > is cleaner in this case). > >


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.