Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (September 2004, week 1)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Thu, 2 Sep 2004 12:03:59 -0400
Reply-To:     Scott Norville <kr2no@EARTHLINK.NET>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         Scott Norville <kr2no@EARTHLINK.NET>
Subject:      Re: Any POR 15 users-field report?

I now have several years on the pan, floor, roll cage and engine compartment of the Thing, and I recommend it highly. Key points: 1. it is hard to paint over, you would need to spray it and top-coat just after it flashes, or fine sand (it will tend to peel then) or use the tie-coat that POR sells (no experience with this) 2. it usually makes a nice smooth, glossy finish when applied with a brush 3. the gloss does not last well (turns dull and unevenly colored) when exposed to sunlight for several years (floor and roll cage) but continues to protect and hold up against wear 4. it sticks best to rougher metal, better even to surface rust, than to fully sanded/polished metal. I have had it peel right off of smooth steel and aluminum. On the other hand, remove all the loose or flaking rust. 5. it sticks even better to you! Wear long sleeves and gloves and a hat. I generally use it in the places that rust but you can't see too often, as it is difficult to "finish" if you don't like black. As my westy has had little problem with seam rust I haven't tried it there.


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.