Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (January 2005, week 1)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Mon, 3 Jan 2005 17:16:25 -0700
Reply-To:     jimt <camper@TACTICAL-BUS.INFO>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         jimt <camper@TACTICAL-BUS.INFO>
Subject:      Re: Stove Repair
In-Reply-To:  <BDFEFB40.9598%bueses@earthlink.net>
Content-type: text/plain; charset="ISO-8859-1"

On 1/3/05 1:38 PM, "bueses" <bueses@EARTHLINK.NET> wrote:

>> Was wondering if anyone else has had similar issues with stove. Haven't >> been able to find any references for disassembly/repair >> of stove for my 87 Westy. >> >> Basically, one burner works fine, the other is the problem. It lights >> but just burns on very low flame even if the gas is full on. I'm >> thinking there might be something in the line but am at a loss as to >> how to take off the burner to get in there. >> >> Any help or advice is much appreciated. >> >> Joe > > Sounds like it needs to be scrapped & the flame spreaders sent to moi! No > really, I need a flame spreader (the cast alum? Piece on the burner top) as > I was careless in cleaning the stove top & the spreader got loose & started > to melt when I ignited the burner one a.m. Has this ever happened to anyone > else? All I can figure is that w/ it loose, it blocked the heat which > caused it to concentrate on the spreader & overheat it. > > Anyone want to sell moi an extra one or 2? > > Pax, > > Tom Buese-getting ready for Buses by the Bridge IX & need 1 badly > > Just finished doing a 100 percent disassembly of my sink/burner unit about 20 minutes ago.

Going backwards

Flame spreader/mixer unit

Main flow/expansion tubing

Valve/orifice unit

A low flame in this design could be Clogged spreader Spider webs dust in the tubing Contaminant got down the tubing and to the orifice

A drop in the sink and scrubbing out for the spreader unit A blast of compressed air from a can down the tubing to clear out spiders etc.

If it is the orifice/valve you have a tricky job of getting the unit out of the van.

Then removing the spreaders looking into it you will see two bent over metal pins. Pull these. Then knocking counter clockwise line up the knotches in the rings. Remove screw in spreader assembly base. Remove base and locking ring. Remove screw under that unit. Repeat for both burners You should then be able to carefully remove the gaskets at the bases. Very carefully.

Then flip over and unit should then be removeable from the base.

The orifices go through the tube to the spreaders and must be very carefully cleaned or you can make it worse and the only way to tell is after you have it all hooked up again.

Right now I am checking to see what orifices are available for these units. If I cant find the larger ones I will be selling this unit. I want at least one 6500 btu burner for my needs. •••••••••••••••••••••••••••••••••••••••• jimt Planned insanity is best. Remember that sanity is optional. http://www.tactical-bus.info (tech info) http://www.westydriver.com


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.