If the heads have any cracks between the valves (even small) they are junk and should be replaced. However with 190k miles on the engine I am not sure how much farther the whole engine should be expected to go. If money is an issue then you could look around for a good used engine until you can get the money together for a rebuild. If a rebuild is something you can afford I would highly recommend it at this point and I would get it from Boston Engine. My personal opinion is that the main reason why waterboxer engines have such a bad reputation for heads repeatedly failing is that folks put old heads back on with small cracks and within 20k miles they are done and you are doing the job over. Just my 2cents. Ken Wilford John 3:16 www.vanagain.com Jim Felder wrote: > A few minutes ago I finished pulling the heads on my 2.1 in > anticipation of installing new head gaskets and fuel hose. > > Cylinder question: the car has 190K miles on it, and I noticed I could > feel no lip inside the cylinder... none. Upon closer inspection with a > light, I can still see the crosshatch from the factory. Is this normal? > Unusual? > > Head question: I'm not going to do anything to the heads but clean them > up and stick them back on with new gaskets. They are pitted, though, > and I am going the JB weld route. Should I just send the heads to a > shop and have them cleaned? Do it myself? How much should I expect to > pay for just a cleaning? I assume they will have to pull the springs > and valves. > > Thanks, > > Jim > |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.