The power steering racks are not difficult to rebuild, however, you will need to buy or build some special tools to do the job properly. If you decide to do the rebuild yourself, here's a list of parts you may need: 251 498 020, Steering Rack Seal Kit - $81.75 251 419 081, Steering Rack Bushing (4 required) - $2.65/each 251 419 831A, Steering Rack Boot (2 required) - $8.85 Additionally, you should replace the PS filter (431 422 385A) - $8.14 Rebuilt PS racks sell for $225/exchange ($100 core deposit) so it may not be worth your time and effort to perform the rebuild yourself. If you change over to a manual steering rack, you may want to replace the steering knuckles as well since the arm where the tie rod attaches is longer on the manual steering vans. It'll work with your current knuckles, but it will take more effort to turn the wheel. A good used manual rack sells for $90/outright, plus shipping. Good luck. Cheers, Jeff www.vanagonparts.com
-----Original Message----- From: Vanagon Mailing List [mailto:vanagon@GERRY.VANAGON.COM]On Behalf Of Barry Muller Sent: Tuesday, January 25, 2005 1:36 PM To: vanagon@GERRY.VANAGON.COM Subject: Power Steering Woes (longish)
OK The data: 1991 Carat, two years ago the stealership installed a rebuilt power steering rack (PSR) (and all the lines because the we were rusted to the rack) for mucho dinero. They warned me to use VW Powersteering fluid. The manual sez Dexron ATF. First signs of trouble Whilst replacing the radiator I noticed the boots on the PSR had never been installed with hose clamps and were. of course hanging uselessly on the tie-rods. I attached them to the rack and hoped for the best. Today Well of course the 18 mos of grit that was packed agains the seals began its dirty work and now I have an increasing leak-rate. I have added Dexron III, because, of course, they don't sell just Dexron anymore. Now I also see leaks from the back near the pump too. Question 1(a & b): Did I screw-up by putting dexron III in? What are you using and what is your experience with leaks? Q2 (a & b): How bad is it to rebuild the rack with new seals? Is it worth the time/hassle computation, or should I just chalk this up to another expensive lesson and buy a rebuild and install it? Q3 (a & B): Did they ever sell the Vanagon in NA with a manual rack? If so, has anyone done the transplant?
Thanks from, "old greasy driveway" |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.