Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (February 2006, week 1)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Sun, 5 Feb 2006 20:36:14 -0800
Reply-To:     mark drillock <drillock@EARTHLINK.NET>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         mark drillock <drillock@EARTHLINK.NET>
Subject:      Re: 1990 Blinking Coolant Light Mystery
In-Reply-To:  <14dd5cc16c737d91211362a14baff112@mac.com>
Content-Type: text/plain; charset=us-ascii; format=flowed

The blinking light can be caused by either a real drop in coolant level in the main tank, a false reading of a drop in the main tank, or a problem in the dash. If you are sure that the system starts off with no air in it but air appears after you drive, then you have a cooling system problem causing a real drop in the coolant level.

The coolant expands when the engine warms up and the coolant gets hot. Since there is so much coolant, 16+ quarts, the pressure rise in the system from it all expanding forces a little coolant into the overflow tank. The main tank has a pressure cap on it and after the pressure in the system reaches that set pressure, some of the pressure is relieved into the overflow tank. If there is air in the main tank, some of it should be pushed into the overflow tank instead of coolant since the hose from the main tank connects at the top, where air will collect. When the engine cools down, the coolant in the system shrinks back to cold size and this sucks from the overflow tank. Since the hose connects to the bottom of the overflow tank it will suck liquid from it if there is some in it. It only draws a little every time the engine cools, until all the air is gone from the main tank. The system is designed to self bleed, but can only do so gradually and over multiple cycles of heating and cooling of the engine. The engine will NEVER suck coolant from the overflow tank while the engine is running. That is why you must always add coolant to the main tank if the main tank is too low.

If you are always getting more air in the main tank, something is wrong. That air has to come from somewhere. There two likely sources of air in the system. One is steam from boiling coolant. If you have just water or very weak coolant, it will boil too easily where it touches the hottest parts of the engine and make steam that will create a bubble in the main tank. Also, if the pressure cap is bad it will let the coolant boil too easily as well and make a bubble in the main tank The other likely source is combustion gas leaking through the head sealing surfaces and into the cooling system. The combustion gas pressure is over 1000 psi so even a very tiny leak of this gas will make a big bubble in the system and push coolant out into the overflow tank. This may well be your problem. Since it is very expensive to fix this, it is good to eliminate all the easy and cheaper causes before facing up to the worst case.

Mark

> > > i'm still confused as to why the fill tank would be full but the > expansion tank will only read to be at minimum or under? when will the > contents of the fill tank transfer to the expansion tank to fill it?


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.