The fact that the trans will go into tird gear akfter lifting off the throttle tells me that the linkage between the transmision and the throttle is not adjusted correctly. Most likely, there is too much slack. Shorten that threaded rod just before the throttle linkag so the throttle opens earlier, (pedal higher). With the pedal pushed all the way down, that spring should be almost completely compressed. Proper operation is the throttle opens fully, then continuing to push the pedal will put the the trans in down shift mode. Dennis ----- Original Message ----- From: Mark Erb <kasdtech@MAC.COM> Date: Thursday, February 23, 2006 9:07 pm Subject: AT Problem > 1988 Westfalia with 95,000 miles, AT fluid changed 25,000 miles ago. > AT fluid is at the proper level. No AT fluid in the coolant. The > problem that has cropped up is the transmission sometimes does not > want to shift into 3rd gear and will wind out until I let off the gas > for a bit then it will slip into 3rd. The reverse gear will sometimes > not engage right away then will go into reverse with a big clunk. > These problems don't always occur but will happen even with a hot and > cold engine. Anyone else have this problem? Thoughts? A solution > perhaps? I have easy access to transmission shops (AAMCO, Cottman, > even a shop that does german transaxles) but I wanted to at least > have some ideas before I discuss options with a shop or try to tackle > it myself. Thanks for any feedback. Mark > |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.