Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (February 2006, week 4)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Tue, 28 Feb 2006 00:32:34 -0700
Reply-To:     Karl Wolz <wolzphoto@WORLDNET.ATT.NET>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         Karl Wolz <wolzphoto@WORLDNET.ATT.NET>
Subject:      Re: 1.9L starts but wont run long
Comments: To: Jonce Fancher <streetbugs@WHISPLLC.COM>
In-Reply-To:  <vanagon%2006022723441852@GERRY.VANAGON.COM>
Content-Type: text/plain; charset="us-ascii"

Sounds like it's running on the gas that the pump has pressurized and then running out. Have you done a fuel pressure test? Or simply checked the flow - even without the van running?

Karl Wolz

> -----Original Message----- > From: Vanagon Mailing List [mailto:vanagon@gerry.vanagon.com] On Behalf Of > Jonce Fancher > Sent: Monday, February 27, 2006 9:44 PM > To: vanagon@GERRY.VANAGON.COM > Subject: 1.9L starts but wont run long > > Hi all > I took on a Project to help a local list member that is moving out of the country and > needed to sell his late 85 vanagon GL. It had a problem of starting then > stalling out. He had purchased a new fuel pump and lots of other stuff for it and is > now on a deadline to get it running to sell. > > so i put it on the lift and installed the new fuel pump and filter then replaced misc > vac lines that were very old and cracked. charged the battery and turned it > over after priming the fuel pump. > It starts now but only revs to 2k rpm for about 5-10 seconds then drops off and > stalls. ive checked misc items and swapped out the temp 2 sensor on the > thermostat housing as with checked all grounds replaced pump relays and adjusted > most of the linkage and throttle position switch. it revs strong and > sounds good but just stalls off. I did put a gallon of fresh fuel in it since it sat for > some time. It had the same problem before the pump was removed by the > owner. it also does not smell like it is burning oil or over rich. it is smoking on start > but untill it runs i dont like to point fingers till i know its not burn off from > anywhere. Ive had problems with my 2 1.9L in the past but nothing of this sort. > I have not done a compression check but with the way it sounds i really dont have > the feeling i need to do one. > > what did i miss? bypass air reg. doesnt have time to close off in 5-10 seconds. so i > dont thing that is the issue. i did pull the hoses and check air did flow > through it. the Owner did install a new OEM AFM and the boots and hoses all look > good. air cleaner is also new. > > I need to get it running to get out of my garage since i have another project waiting. > for this one to be done > thanks for any suggestions. > Jonce > > Jonce Fancher > > 57 Single Cab > 66 Sunroof Bug > 66 Variant Squareback > 71 Sunroof Bus > 75 911S Sunroof > 84 Vanagon "Godfried" > 85 Vanagon Westi > 2003 10 Passenger Sprinter > > Fancher's Upholstery Inc. - www.fanchers.com > Not-A-VW Club- http://mywebpages.comcast.net/jaransont3/notavwclub/


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.