The early metal engine cover is very little real protection, if any. I have seen plenty of early vans burn so bad that the steering wheel melts, metal engine lid be damned. On Syncros, the fuel tank is right above the tranny and the tank is made of PLASTIC. Long before the fiberglass engine lid burns through, the top of the fuel tank melts and feeds the fire in an unstoppable way. If the tank was completely full it would not melt through but since there is always a little air space inside at the top, the heat trapped by the engine lid does it's damage and the Syncro is history. Kid yourself all you want about metal or insulation to limit the damage done to the interior, the only way to save your Vanagon from fire is to PREVENT the fire in the first place. Mark Doug F wrote: >Ahhh, without looking it up, I think the power for the pump either comes >from the ignition switch or comes from the ECU. > >In either case not sure you can "cross" any circuits in the engine >compartment with a fire that will keep the pump running. > >If that is the case I would like to know which wires exactly are you >referencing. > >The reason the fire is so difficult to fight is that fuel line leaks will >spray the entire engine and engine compartment with fuel before the fire >even starts and then any and everything in the engine compartment is ablaze >including the fiberglass engine lid. > >Once the fire breaks through the engine cover its no problem to set the >ENTIRE interior of the van on fire. >Thats why an early vanagon metal engine cover can save the van all by >itself. > >If I had a place to do it and a parted out vanagon to test I would love to >test out various barriers in the back like a thin piece of sheet metal over >the engine lid or nomex fabric blanket or both and see if the fire could >intrude into the interior. > >Doug > > |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.