Date: Tue, 14 Mar 2006 19:48:03 -0600
Reply-To: Max Wellhouse <maxjoyce@IPA.NET>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: Max Wellhouse <maxjoyce@IPA.NET>
Subject: Re: [vanagon] Re: Vanagon Engine Temps & Oil Levels
In-Reply-To: <dv7mq2+qca1@eGroups.com>
Content-Type: text/plain; charset=iso-8859-1; format=flowed;
x-avg-checked=avg-ok-345E62DA
If I needed to calibrate my VDO gauge, I would set up the Coleman propane
stove, boil a pot of water, suspend the sending unit in the boiling water,
make sure I had an external ground wire attached, turn on the ignition
switch, and see what the reading was. Then do the math for number of feet
above sea level. I recently bought an NOS VDO dipstick sender off ebay for
a couple bucks. It was dead on at 100 degrees C. the last time I checked
it. Maybe that VDO sender I put in the oil drain plug hole has been lying
to me! Certainly hope it was on the optimistic side.
DM&FS
At 06:23 PM 3/14/2006, dontemail2002 wrote:
>It's been my experience with automotive oil and water temperature
>gauges that they have not been very accurate. In order to know what
>your oil temperature is you must calibrate your gauge or use a
>calibrated thermometer.
>
>You can calibrate your oil pressure gauge with boiling water but this
>is somewhat difficult to do.
>
>You can accurately measure your oil temperature by strapping an
>electronic thermometer probe (calibrated of course) to your oil filter
>with a plastic wire tie and covering it with a piece of insulating
>foam. By comparing this reading to your gauge reading you can
>calibrate your gauge.
>
>I found my VDO gauge was quite optimistic with it's reading. However,
>it was always quite precise, giving the same reading (incorrect,
>however) at the same temperature.
>
>I agree 100% with Karl about the desired oil level. I've done the
>same experiments and have gotten the same results. When I had a 2.1L
>WBX I ran the oil level at the lower end of the suggested operating
>range plus 0.25 quarts. I found an the oil temperature never got
>above 210ºF under any conditions and usually remained at 195ºF (IIRC).
>
>Ed
>Raleigh, NC
>
>
>
>--- In vanagon@yahoogroups.com, dylan friedman <insyncro@...> wrote:
> >
> > I am only going on my experience with starving an engine of oil and
>the damage it will cause. Most people do not watch the car they drive
>as closely as you and I. if they run it low for what ever reason and
>do not monitor it, kiss it good bye.
> >
> > df
> >
> > Karl Mullendorf <syncrosixteentdi@...> wrote: To quote Dennis
>Haynes' ACTUAL REAL-WORLD TESTING [read: not some
> > theory spouted by your A.C.E.'s:
> >
> > ************************************************************
> >
> > "I have done the testing, both intentionally and by mistake.
> >
> > The FUN BUS has a 16 plate thermostatically controlled oil cooler in
> > place of the OEM oil to water heat exchange. The oil pressure gauge is
> > connected to the port at the center cam bearing, (between the push rod
> > tubes). The oil temperature sensor is installed in the lower oil
> > pressure relief valve plug.
> >
> > At normal speeds and oil fill the case or oil temp will follow the
>water
> > temp. On hot summer days with the AC on and traveling ~ 70 mph, I will
> > see ~210-220F. If I change the oil and add a full 5 quarts, I will see
> > maybe 230F and the pressure will start dropping. If filled with 5.25
> > quarts, It will go to 240-250. If I run to 75 or run the engine at
>4,400
> > to 4,500 rpm for extended period, the oil temp will actually run
>away to
> > 270 or more and when slowing, the oil pressure will plummet until
>things
> > cool off. this is a good test for the oil pressure warning buzzer.
> >
> > Overfilling is probably the most common cause of the oil pressure
>buzzer
> > sounding intermittently. Especially during extended highway drives.
> > Folks that think they solved the problem by changing the oil filter
>are
> > misled. It was not the filter change that fixed it, it was the
>lower oil
> > level after the filter change or different driving conditions. The WB
> > has got to be one of the most oil level sensitive engines out
>there. To
> > make things worse, the sum playout is such that engine angle makes it
> > difficult to get a consistent oil level reading. The engines mounting
> > makes it worse as the engine leans forward away from the dip stick.
> >
> > When I change the oil, i ad 4.5 quarts and give the remaining .5 quart
> > to the customer and instruct them not to add until the level is at or
> > below the lower line."
> >
> >
>************************************************************************
> > Since both of you refuse to consider hard data presented, then
>who's the
> > [choose your descriptive word] here? Too bad you can't accept
>input,
> > too hard-headed and know-it-all, wonder how any improvements happen in
> > the world with the Idea Police on guard!
> >
> > Karl
> >
> >
> > dylan friedman wrote:
> > > Terry,
> > > I have discussed this same topic with just as credible engine
>builders
> > > and racers.
> > > I receiving the same answers and found the laughing to be louder
>than
> > > waterboxer tapped out on the highway. I thought this was common
> > > knowledge, but had to check as well. if someone wants to run
>there wbx
> > > low on oil and feel good about it, I think many know they have
>pulled
> > > the pin on that gernade. Fire in the hole!
> >
> >
> > To leave this list send an 'empty' message to
><mailto:vanagon-unsubscribe@yahoogroups.com>
> >
> >
> >
> > SPONSORED LINKS
> > Volkswagen car
>cover Volkswagen radiator
> Volkswagen parts
> Volkswagen dealer sc
> Vanagon
> Vw vanagon
>
> >
> > ---------------------------------
> > YAHOO! GROUPS LINKS
> >
> >
> > Visit your group "vanagon" on the web.
> >
> > To unsubscribe from this group, send an email to:
> > vanagon-unsubscribe@yahoogroups.com
> >
> > Your use of Yahoo! Groups is subject to the Yahoo! Terms of
>Service.
> >
> >
> > ---------------------------------
> >
> >
> >
> >
> >
> > ---------------------------------
> > Yahoo! Mail
> > Use Photomail to share photos without annoying attachments.
> >
> > [Non-text portions of this message have been removed]
> >
>
>
>
>
>
>
>To leave this list send an 'empty' message to
><mailto:vanagon-unsubscribe@yahoogroups.com>
>Yahoo! Groups Links
>
><*> To visit your group on the web, go to:
> http://groups.yahoo.com/group/vanagon/
>
><*> To unsubscribe from this group, send an email to:
> vanagon-unsubscribe@yahoogroups.com
>
><*> Your use of Yahoo! Groups is subject to:
> http://docs.yahoo.com/info/terms/
>
>
>
>
>
>
>
>--
>No virus found in this incoming message.
>Checked by AVG Anti-Virus.
>Version: 7.1.375 / Virus Database: 268.2.1/279 - Release Date: 3/10/2006
--
No virus found in this outgoing message.
Checked by AVG Anti-Virus.
Version: 7.1.375 / Virus Database: 268.2.1/279 - Release Date: 3/10/2006
|