Date: Mon, 5 Jun 2006 22:39:38 -0400
Reply-To: Jonce Fancher <streetbugs@WHISPLLC.COM>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: Jonce Fancher <streetbugs@WHISPLLC.COM>
Subject: 1.9L to 1600 T-1 Distributor
Content-Type: text/plain; charset="iso-8859-1"
Well not all vw distributors are the same.
during assembly i tend to install the dist drive gear and point the rotor in the firing of #1 and then install the crank with #1 rod out. then gently spin the crank
to drop in the cam. Well the type 1 Distributor that ive used for many many motor builds is NOT the same as the 1.9L vanagon dist. so apparently the rotor is
about 90 degrees off from one to the other. Not a biggie just pull the drive gear and spin it 90 Deg and drop it back in TADA. Well lets Oops again i had the
crank on BTDC not TDC. So now im simply 180 deg out. SOOOO put the gear rotate Crank to TDC then drop in the gear one last time. Cranked the beast
and it sputtered so i spun the dist. just a bit more advanced and shebang it was off and running.
did a quick check the timing at idle not warm then ran her up to 3k to try and break in the new pistons and cyl. Oil pressure was fantastic with no oil or water
leaks anywhere. I had it on the 3 k mark for about 5-7 min is all then shut her down. checked temp on the exhaust pipes and all where in the same temp
range so i know im firing on all cyl. it sounded Clean and smooth with plenty of power but. just as i was getting ready to drop to idle i noticed a bit of a sputter.
like a cylinder was dropping off. Ive had issues in the past with over charging lifters. it sounded like that but ive not had it running more then the 5-7 min. Not
concerned as of yet but will see when i play with it again tomarrow.
So i guess ive got a quick question What is the break in time for a 1.9L? and any special things to look for during break in.
c-ya Jonce
Jonce Fancher
57 Single Cab
66 Sunroof Bug
66 Variant Squareback
71 Sunroof Bus
75 911S Sunroof
84 Vanagon "Godfried"
85 Vanagon Westi
2003 10 Passenger Sprinter
Fancher's Upholstery Inc. - www.fanchers.com
Not-A-VW Club- http://mywebpages.comcast.net/jaransont3/notavwclub/
|
Back to: Top of message | Previous page | Main VANAGON page
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives
@ gerry.vanagon.com
The vanagon mailing list archives are copyright (c)
1994-2011, and may not be reproduced without the
express written permission of the list administrators.
Posting messages to this mailing list grants
a license to the mailing list administrators to reproduce
the message in a compilation, either printed or electronic.
All compilations will be not-for-profit, with any excess
proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively
towards the management and operation of the Vanagon mailing
list and vanagon mailing list web site.