If you really got a few years out of an Optima, you did good. It is a technology that still doesn't work as advertised. I am even considering a return to flooded batteries for UPS systems at work. The sealed batteries fail without warning and in a UPS, usually when you need them the most. One thing to check is the relay. Due to the usually small currents they pass, they will sometimes oxidize and have a high resistance. With the relay energized, check the voltage to ground on both sides. It should be equal. It should also close the voltage at the alternator if the wiring is sufficient. I have also found some engines have a nasty voltage drop through the case, etc. Measure from the alternator case to the body or chassis. If you see a voltage drop, add another ground strap there. I have seen over .5 volt on some engines. Guess what, this drop is also a problem for the O2 sensor circuit. Dennis -----Original Message----- From: Vanagon Mailing List [mailto:vanagon@gerry.vanagon.com] On Behalf Of Chris Paquette Sent: Wednesday, July 05, 2006 5:52 PM To: vanagon@GERRY.VANAGON.COM Subject: '88 Westy: Aux Battery Problem Like many listees, I have an Optima Yellow Top under the driver's seat to use as an auxiliary battery. I had my mechanic arrange it so that the interior lights, stereo, and inverter would draw power from it when the ignition was off. However, I've never managed to get it to stay charged. The first Optima Yellow Top I bought died after a couple of years and would not take a charge. When I was at GoWesty for some other work I had them check the wiring and they said it looked fine. Nonetheless, the Optima - which I thought could not be killed - was dead. It was thought initially that the culprit was a small dash display from my CD changer - it was an LED readout that said "Stand By" whenever the CD changer was off, so it was a small but constant drain on the aux battery system. Recently I got a new stereo and had them remove the CD changer to eliminate that draw. Then I bought a new Optima and put it in two weeks ago. When I got in the bus yesterday, I noticed that the interior lights didn't come on. Bad sign. I have a voltage meter I can check the aux battery with and it was down to 7 volts. I have no idea what could be drawing any power from the aux battery now. Any similar experiences or suggestions? I'm frustrated that I can't get the system to stay charged. When I take it back to my mechanic this time I'd like to be armed with some ideas on what the problem might be. Thanks for any thoughts. Chris Paquette '88 Westy, "Rocinante" Los Angeles |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.