In a message dated 8/31/06 4:30:25 AM, rfeussner@GMX.DE writes:
> Finally, after more than 1.5 years, I completed my V6 TDi conversion. > > http://kfz.freepage.de/rfeussner/IMG_1802.jpg > http://kfz.freepage.de/rfeussner/IMG_1804.jpg > http://kfz.freepage.de/rfeussner/IMG_1806.jpg > > And more Photos on http://kfz.freepage.de/rfeussner/v6tdi > > Raimund > > Raimund, Very impressive piece of work and engineering! A translation would be helpful. I assume that the gearset photos are of a set of spur gears you designed to reverse the direction of rotation of the axles from the front-wheel drive Audi Tiptronic. If so, what aluminum alloy did you use for the case and have you seen any deformation of the bearing carriers? Some time ago, I experimented with the possibility of developing an overdrive units for my vanagon TDi conversion. Here, I thought I could develop a good compromise between the low gearing in the readily available 4-speed manuals and a cruising speed gearing of 0.7 convolved with the standard 4th gear ratio. I was basing the units on the Laycock de Normanville all electric overdrive units so common on Volvo turbo 4-cyl sedans and wagons. My solution was to develop a carrier to fix the overdrive unit to the transmission at the point of each output shaft and use an adapted Porsche CV joint at the end of the OD unit. The axle shafts would have to have been shortened significantly and the max angle tolerated by the Porsche CV units was right at the limit. But your parallel shaft approach could drastically reduce the shortening length. A quick look at my CAD file suggests that this would shift the CV joints to a point very close to the original gas-powered location. This would give the equivalent of a 7 speed transmission - shades of a real truck! With standard tires that would correspond to 2,500 rpm at 70 for the DK trans and 3,250 for the DZ. Or 110 mph top speed within the normal TDi power band on the DK, 0r 90 with the DZ. Frank Grunthaner |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.