Date: Mon, 2 Apr 2007 08:18:26 -0700
Reply-To: TC <trclark@SHAW.CA>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: TC <trclark@SHAW.CA>
Subject: Re: Wiring harness problem
Content-type: text/plain; charset=iso-8859-1
> Hello I am the guy with the smoke problem last week.
>While cleaning and inspecting my new Vanagon I found a one foot section of
my wiring harness
>(were it goes along behind the license plate)
>that got hot enough to make all the wires stick together and become
brittle.
>They are not shorting out but it doesn't give me any confidence.
> I could repair my wires but I am hoping someone out there who has done an
>engine conversion would have a decent one I could buy of off them.
> 1983 Water cooled anyone? It is the main harness that goes to the fuel
injectors.
I rebuilt my whole harness a few mths back
so ...
when you do get a new to you harness dont put that crappy plastic sheild
back
get this
http://cableorganizer.com/convoshield/
or
http://www.tessco.com/products/displayProducts.do?groupId=619&subgroupId=30
That Bentley-Harris ConvoShield will give you the best protection
& dont just replace the shield on the one spot above the exhaust
replace it all especially on the runs to the FI's dont leave any wire
exposed like the std harness
take the split loom conduit right upto the rubber boots on the fi's the 2 on
left above the exhaust you will probably find
the wires on those fi's are brittle so I would replace all the fi connectors
with these
http://www.msdignition.com/fuel_10.htm
|
Back to: Top of message | Previous page | Main VANAGON page
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives
@ gerry.vanagon.com
The vanagon mailing list archives are copyright (c)
1994-2011, and may not be reproduced without the
express written permission of the list administrators.
Posting messages to this mailing list grants
a license to the mailing list administrators to reproduce
the message in a compilation, either printed or electronic.
All compilations will be not-for-profit, with any excess
proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively
towards the management and operation of the Vanagon mailing
list and vanagon mailing list web site.
