Date: Fri, 29 Jun 2007 10:17:09 -0700
Reply-To: neil <musomuso@GMAIL.COM>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: neil <musomuso@GMAIL.COM>
Subject: Re: Second Request Help Needed w/Aux Battery Wiring
In-Reply-To: <86476e250706291002m3cd3f56eh4f618ccb3124689f@mail.gmail.com>
Content-Type: text/plain; charset=ISO-8859-1; format=flowed
A quick look at P97.34b of Bently doesn't show any acc. connections to
aux battery. But that doesn't mean much
I would disconnec the connector (two black? wires) and see if sink
pump stops working.
That would elminate one set of wires.
One of the red wires must be supply to relay that would continue on
(when relay energized) to Pos post or aux battery.
Beyond that it's a little hard (for me anyways!) to see exactly what is what.
I've never hooked up an electronic isolator, so can not advise in that regard.
On 6/29/07, Loren Busch <starwagen@gmail.com> wrote:
> The van is a '90.
> And yes, everything was (and still is) working fine. Right now I've
> connected the new battery, through heavy cables, to the same points the old
> battery was connected to and everything is working fine.
>
>
>
> On 6/29/07, neil <musomuso@gmail.com> wrote:
> > Not to be critical, but is there an image showing wires in a less, uh,
> > messy way?
> >
> > The little silver box is a relay. Likely the isolator relay. And yes
> > it is most likely grounded throught the case.
> >
> > Was the battery functioning before?
> >
> > The best way to trace wiring is to disconnect ALL batteries, consult a
> > wiring diagram, and when you narrow it (mystery wire) down to a few
> > (or one) wire, disconnect it, ground it, and check for continuity with
> > a VOM.
> >
> > What year is van?
> >
> >
> >
> > On 6/29/07, Loren Busch <starwagen@gmail.com> wrote:
> > > Sorry for the repeat post but got no answers at all to the first post.
> > > In the process of going to a larger aux battery (under the rear seat)
> I'm
> > > also planning on going to a Surepower 1315 separator rather than the
> current
> > > relay setup. Now that I'm looking at the rats nest of wiring that
> already
> > > exists in the aux battery box I'm confused. Picture here:
> > >
> http://picasaweb.google.com/starwagen/AuxBatteryCompartment/photo#5081175084108326066
> > > The two red wires that disappear to the lower left connect to what I
> assume
> > > is a relay, mounted in the 'hidden' space with two bolts that go through
> the
> > > body into the wheel well, nuts in the wheel well.
> > > If the gurus can take a look at the picture and tell me a little bit
> about
> > > what I'm looking at I'd really appreciate it. Like what is the little
> square
> > > silver box at the top of the picture? Seat belt buzzer? Or what? And
> if
> > > the relay (that is hidden) is the 'Aux Battery Relay' I have to assume
> that
> > > it grounds through the case (only two wires to it).
> > > Any definitions would help so I can sort these wires out .
> > > Thanks in advance.
> > >
> >
> >
> > --
> > Neil Nicholson. 1981 Air Cooled Westfalia.
> >
> > http://web.mac.com/tubaneil
> >
>
>
--
Neil Nicholson. 1981 Air Cooled Westfalia.
http://web.mac.com/tubaneil
|