Okay, the 91 non-GL Syncro I bought last year, had a crappy FM only radio. I had a Pioneer AVIC N2 to put in its place. Since I had bought from Crutchfield they had a lovely harness adapter so that I could keep the "stock" wiring. So I pulled the original (don't think it was OEM, but it still used the stock wiring ) radio. And started installing the Pioneer. Wired up all the speakers, and hot lines, illumination and "acc" line (hooked to the X circuit on the Vanagon.) Attached ground and tried the unit (not yet installed in the dash.) Nothing. Double check my wiring. All fine...Double check the adapter wiring to factory connector....all fine...except. The factory wiring had no ACC wire (plug, yes, but no wire.) Well that explains a lot. So I crimped into a nearby X wire (black/red going to the front air switch) Voila. It worked. Of course in order to get to that wire I had to pull the levers off and broke one. Sigh. Then I had to route the wires to the "remote" unit of the Pioneer. This is part of the GPS navigation system. It has to be oriented flat (so I couldn't hide it behind the glovebox for example. So under the front drivers seat it went. I routed the cable under the rubber mats (had to lift up the accelerator pedal to do so.) There were 3 cables. Extender cable for radio antenna. Main connector (multipin) between the pioneer units, and a cable to the emergency brake switch. All connected, all happy. Went to reconnect the accelerator pedal and the rod at the top came up in my hand. Sigh. Under the car and remove the cover (so I had light and could see what I was doing.) Then reconnect the rod, and the pedal. Easier than I thought it was going to be. Then I had to button it all up again. There's a reason install places charge a couple hours for this type of thing... |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.