Date: Sun, 26 Aug 2007 21:29:59 -0700
Reply-To: Thomas Pfrommer <pfrommer@PHAS.UBC.CA>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: Thomas Pfrommer <pfrommer@PHAS.UBC.CA>
Organization: University of British Columbia
Subject: Speedometer cable -- trip report to the Okanagan
Content-Type: text/plain; charset=ISO-8859-1; format=flowed
Hi list,
first the good message:
We had a really nice trip to the Okanagan and everything went smooth,
regarding the rebuilt engine with now about 3000km on it. Drove about
3600rpm (=100km/h on flat terrain) The oil pressure (first regular oil
change just before the trip, third after rebuilt) was slowly going down
from 28/29psi to perhaps 25psi within 1.5 hours from Vancouver to Hope
(very tiny slope over more than 130km). Coolant temp was just touching
the lower side of the warning light. Then the Coquihalla came and I had
to give full throttle for maintaining about 65km/h, the oil pressure
went down a bit but still around 18/19psi at 2800rpm at the lowest
(hottest), water temperature rose but not more than just passing the
warning light, the radiator fan brought it slightly down. After this
hard bit the engine still run great and smooth all the way to the
Okanagan, with a short stop in Merrit to get some gas. Something really
cool is the last I'd say 30km from the 97C (the connection) to the
Okanagan lake. It always goes down at about 55 or so, and I maintained
100km/h without touching the gas pedal the entire route. Also no brakes
are needed. While still running at 3600rpm, the oil pressure rose to
33psi as the engine cooled further down. This is really cool; from 22psi
to 33psi at the same rpm just through temperature changes!
We stayed for a couple of nights on the lake ad going back i had a scary
moment while driving up a dirty slippery road (=just wide enough for the
van). I was alone on the van as there was one corner that I did not want
to have my family in the car ... too scary. Well this corner went well,
BUT then another car came from above and as it was way to steep could
not back up. Instead of getting out of the van and look what would be
the best to do, I backed up slowly, but came a bit too high (did not
want to get too close to the inner falling corner of this slippery edge,
but the high side had an even higher large flat stone, which made it
worse) and then had to turn the wheel to not roll over down the hill.
Sure enough the wrong direction, which brought me in a really bad
situation. I would even say, my kangaroo bumper prevented me from
rolling. Sorry no photos shot as I was too afraid of this entire
situation. But I can tell you it was the definite limit of a van to not
fall over sidewise. Anyway a fried called an uncle with a big 4x4 truck
to stabilize my front end and other friends stood at the opened sliding
door to get more weight on this side, ready to jump in case I would have
had rolled to the other side, and then I basically drove out by myself.
Pooh a bit too much excitement, i can tell you.
The other car sure enough had had a possibility to find a spot for me to
squeeze by in the end (he knows the rod way better, I wonder why he did
not pull over in first place).
Anyway the way back was smooth with no more excitements, got some nice
fruits on the way back and the speedometer cable died. Well not a big deal.
I pulled it at the speedo and noticed, it is not turning anymore,
however I feel some vibration while driving. After reading in the
archives, its apparently quite bad to replace the cable, but I guess i
don't have much choices. Before ordering from Busdepot, I should check
if it is the cable, I guess The cable looks nice square on the speedo
side, Even if the upper cable looks nice should I still replace both at
the same time? Or should I go with the one long cable? Whats the
difference?
The Bentley advice looks quite straight forward. is there anything more
to take care of?
Do the Busdepot cables come with the small clip for the hub? One thing I
noticed before failure (not just before but actually all the time I have
this Van) is, that at about 50-60km/h thecable was quite jumping +-
5km/h ad noisy, above 70km/h it was way quieter and stable.
Sorry for the long report and
Thanks
Thomas
(I still have to change my tires ... looks like Discount Tire does not
have the HankookRA08 in stock, I will call them tomorrow to find out. I
think I will go with the 195 ones, if possible.)
|