Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (December 2007, week 1)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Tue, 4 Dec 2007 09:31:03 -0800
Reply-To:     Steven Smith <kewsps@YAHOO.COM>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         Steven Smith <kewsps@YAHOO.COM>
Subject:      Re: coolant blinking, refresh my memory...
Comments: To: robert feller <syncro.carboncow@gmail.com>
In-Reply-To:  <159070990712031643g6cfe0873l2d7aee3a6208b9fc@mail.gmail.com>
Content-Type: text/plain; charset=iso-8859-1

Shawn,

My relay is located under the dash approx behind the left headlight (inside the car). You have to remove the instrument cluster to get to it from the top of the dash or possibly remove the fuse panel to get to it from the bottom of the dash. On my 84 there are two relays next to each other in this location. One has I believe as 24 on it and is for the radiator fan (not exactly sure) and the other has either a 43 or 42 on it for the coolant level sensor. The relays are ALL interchangeable so don't put the 42 in the 24s place by mistake as it is an expensive part ~$80 if memory serves.

From everything I have learned from this board and personal trial and error, the relay is probably the last thing I would change. It is likely the guage itself.

I stopped mine from blinking by removing the nut on the back of the temp guage that is in the center of the 3 nuts that hold the guage in place. It looks different than the other two. BTW: some on this board have advised that this nut could be tightened slightly to solve this blinking light problem. Your might try this. It seemed to work for me for a little while.

Steven

robert feller <syncro.carboncow@gmail.com> wrote: Steven,

You mentioned the relay I'm inquiring about. Where is it located? It may not really be a relay but I believe that is what everyone calls it. I have no problem disconnecting the bulb as I am install a water temp gauge (to compliment my oil pressure gauge).Did you just clip the LED lead?

Shawn

On Dec 3, 2007 9:47 AM, Steven Smith <kewsps@yahoo.com> wrote: Shawn, I spent a lot of time on this one and too much money, only to disconnect the light in the end. My conclusion was that either the gauge was faulty or the resistor in the temp circuit (on the back of the instrument cluster) had changed its value due to age.

Someday if I can find a new resistor I will replace it, but I checked everything there was to check and replaced the relay and coolant sensor, check continuity of wires and total resistance in the circut and found nothing that fixed the problem.

Good luck! Let us know if your have a break through on this one. Steven 84 Westy

"syncro.carboncow" < syncro.carboncow@GMAIL.COM> wrote:

Not overheating Coolant level sensor checks out

.but getting intermittent blinking that often resets with a ignition restart. I seem to recall there is a relay for the level sensor. Can someone refresh me.

Shawn

--------------------------------- Never miss a thing. Make Yahoo your homepage.

--------------------------------- Be a better sports nut! Let your teams follow you with Yahoo Mobile. Try it now.


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.