Vanagon EuroVan
Previous messageNext messagePrevious in topicNext in topicPrevious by same authorNext by same authorPrevious page (March 2008, week 2)Back to main VANAGON pageJoin or leave VANAGON (or change settings)ReplyPost a new messageSearchProportional fontNon-proportional font
Date:         Thu, 13 Mar 2008 11:20:58 -0400
Reply-To:     Roger Sisler <rogersisler2000@YAHOO.COM>
Sender:       Vanagon Mailing List <vanagon@gerry.vanagon.com>
From:         Roger Sisler <rogersisler2000@YAHOO.COM>
Subject:      Re: A/T was run with low oil too long ...

Since it still grips tight when in drive, I would suspect that the body of the trans is still good, or good enough. The valve body directs the shifting, and this seems to be a shifting problem.

The valve body is the lowest point on the transmission, and may be starved first. Just my guess. If all the fluid is needed for circulation in the transmission, leaving the valve body starved.I dont know the circulation pattern for the fluid, but this seems possible to me. When the fluid is foamy from overfill the Vanagon trans wont shift, and slips. Foamy acts like low fluid. Trans will slip and reengage over and over as liquid and foamy fluid is supplied to the tramsnission at different times.

Valve body swap is EZ. Done it several times before. There are no rubber pieces inside the valve body. Only aluminum and steel. I understand that the pistons can get scored. Bentley shows a good exploded view. I found a valve body from a Audi 5000 in my 85. Messages here in the vanagonlist archives show where I made this discovery,I think. I think several different valve body swaps from other VW cars are possible, but shift points may be a little bit changed.

Good luck


Back to: Top of message | Previous page | Main VANAGON page

Please note - During the past 17 years of operation, several gigabytes of Vanagon mail messages have been archived. Searching the entire collection will take up to five minutes to complete. Please be patient!


Return to the archives @ gerry.vanagon.com


The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.

Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.