My daily driver broke a top stud (2nd from front, left side, looking down at engine at rear of van) and that created bad water leak at stud. Local VW shop says "stud breakage rare w/ 85 water Vanagon engines" and he thinks "OK to replace only one stud" and continue down the road..... I'm thinking.....$75 for 1/2 gasket set already, why not complete BOTH sides, replace ALL STUDS (there is visible rust on 50% - engine has MANY MILES), both head gaskets, etc. But that got me into this logic: remove cylinder jugs, re-ring the pistons, reseal the jugs, etc. Why stop there.....pouring gas into the intake/exhaust shows my valued are holding seal (is that OK check?) so perhaps I'll just "lap the values" myself, replace the head gaskets, etc. after doing the re-ring job and I'll be good to go! Pls. fine tune my logic here - where do I stop. The gasket set is about same cost for both sides as one, the rings ?>>>, the lapping process I can handle, so why not? Pls. advise - what would you do in my case? Lots of miles on a junkyard motor I put in 8 years ago so I've been lucky - due time for some renewal of parts, correct? PS. How is the re-ringing process handled? Who best to purchase these rings? Micing (measurement) process? Etc. Thanks for advance info. on this work.... Have a good day! Larry Word Ga. |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.