Date: Wed, 28 May 2008 15:15:09 -0700
Reply-To: Scott Foss - Shazam <scottdaniel@TURBOVANS.COM>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: Scott Foss - Shazam <scottdaniel@TURBOVANS.COM>
Subject: Re: Road trip and mechanics litany of issues
In-Reply-To: <cb6.2e25b67f.356f298e@aol.com>
Content-Type: text/plain; charset=ISO-8859-1; format=flowed
IF it's a waterboxer, i've never seen a problem with an oil gallery plug
by the flywheel seal, fwiw.
scott
Steve Cotsford wrote:
> If there is really an oil gallery plug leaking you should really worry
> but...how can he tell without pulling the engine out? If you have a little oil
> leaking from between the back of the engine and transmission, I do not see how
> it could be identified as anything other than the rear crankshaft seal without
> removing the engine and pulling off the flywheel/flex plate. Sounds a bit
> like a scare tactic to me.
>
> I had an oil gallery plug come out of my 1.7 aircooled VW camper engine,
> behind the flywheel, and it caused the crank to seize. It pumped all of the
> engine oil out within 2 miles, scrapped the crank and crankcase and I had to
> rebuild the entire bottom end of the engine. It was not fun.
>
> I would be inclined to get a second opinion from a known (or another) VW Van
> expert before getting into something expensive.
>
> It does sound like you need at least a little brake work and perhaps a new
> water pump. If the pump has leaked it probably wont last much longer.
>
> Good luck,
>
> Steve
>
>
> ----- Original Message -----
> From: "A. Hurley" <ahurley@VIEWIT.COM>
> To: <vanagon@GERRY.VANAGON.COM>
> Sent: Tuesday, May 27, 2008 11:39 PM
> Subject: Road trip and mechanics litany of issues
>
>
>
>> So...I need to drive from Seattle to Aracta, CA and took my van in to a
>> mechanic for an oil change, belt change and checkup.
>>
>> He came back with all this:
>>
>> Left front brake caliper is sticking, pads worn to 20% ($600?)
>>
>> Runs lean - needs tune up (adjust the mixture screw?)
>>
>> Fly seal and galley plug leaking
>>
>> Front heater valve leaks (not losing much)
>>
>> Water pump has stain at weep hole
>>
>> Right ball joint bad, need upper boots
>>
>>
>>
>> So...estimate is about $1500, and recommend I don't go to CA Friday....
>>
>> Any advice or opinions?
>>
>> Thanks,
>>
>> Andree
>>
>>
>>
>>
>>
>> Sincerely,
>>
>> Andree Hurley
>> Viewit.com - http://viewit.com/
>> Kayak Instruction Newsletter -
>> http://onwatersports.com/KIX/Newsletters/KayakNewsletterSpring08.html
>>
>
>
>
>
>
> **************Get trade secrets for amazing burgers. Watch "Cooking with
> Tyler Florence" on AOL Food.
> (http://food.aol.com/tyler-florence?video=4&?NCID=aolfod00030000000002)
>
>
>
|