> > -----Original Message----- > From: Vanagon Mailing List [mailto:vanagon@gerry.vanagon.com] On Behalf Of > David Beierl > Sent: Saturday, February 28, 2009 7:48 AM > To: vanagon@GERRY.VANAGON.COM > Subject: Re: Engine stutters, tach nosedives. Then, just as suddenly, it's > normal again. > > At 08:38 PM 2/27/2009, Greg Potts wrote: > >> I suspect the coil or the hall sensor; though Mark Dearing at Salem >> Import suggested it could also be the ECU. >> So what do you'all think? Was it just a loose plug wire, or are there >> deeper issues lurking? >> > > Deeper issues. The tach is driven off the coil primary negative > side, which the ECU ignition drivers pull down toward ground and > release in order to create the spark. It is my belief that an open > circuit in the coil secondary -- from unplugged distributor wire -- > would not alter the primary characteristics enough to prevent the > tach indicating, though I could be wrong. No, you are correct here. The coil doesn't care whether there's a coil wire in the tower or not, the ICU/ECU still collapses the primary field and the Tach will see that as a valid signal. If, however, you have an intermittent SHORT between the primary and secondary windings in the coil (BTDT), then you'll have similar symptoms, and the tach will go nutso whenever it starts missing/crapping out. Shorts in the coil *usually* start causing problems when Hot, but not always. Since, however, the coil heats and expands as you run the engine (flexing the primary/secondary coils in the dielectric oil), you should notice a difference in performance (either better or worse) the longer the engine runs. > I think you're looking at > a short in the Hall-effect sender plug at the distributor, which is a > known soft point, or ECU internals or wiring between the two. Most likely culprit IME. BTDT too! Keith Hughes '86 Westy Tiico (Marvin) |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.