So here I sat pretty smug in knowing that I was taking good care of the rear heater core of our 1991 westy. Having been on the list since 1996, I have read all the conventional wisdom on how to keep the core from leaking so I change my coolant every 2 years and leave the valve in the open position year round so that coolant constantly flows through the core. In my demented mind, that would guarantee a sound core forever. On our overnight trips, we keep our clothing under the rear seat so every time I open the back seat, I look for a visible leak and have never seen one until last week. I was surprised to see a small amount of coolant behind the floor of the rear seat, so I removed the protective cover from around the heater. Looking down, there was no obvious leak and everything looked fine. I then went to remove the two screws holding the heater assembly to the floor. One of the screws had rusted in half while the other screw was completely sound. I removed the assembly, disconnected the hoses and then inspected the heater core. It was obvious that the core had been leaking for awhile, collecting in the plastic housing, and must have been dripping and collecting on the screw on the side nearest the fridge and eventually rusted it through. Of course the van tilts in that direction so that makes sense. However, we never noticed the "sweet smell" that others have reported. Anyway, if you have not checked your rear heater core in awhile, I advise taking the five minutes it takes to remove the protective cover and remove the two retaining screws and just inspect the housing assembly even if you don't remove it completely from the van. You might catch a problem before it gets too messy. We have a big trip planned this summer and I am so glad I found the problem before our trip started. Harold ___ Harold Teer 1991 Westy (Vangaux) Harrisonburg, VA |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.