I've posted this, (or similar) on VW Vortex, but received limited response. Situation has been around for about 2 years; gradually getting worse, but still fairly infrequent (maybe once a week, though sometimes a few times in a day). Stop car to run into store, etc. Come out, cranks, no start. Walk away for a while and might start; might not. Sometimes no start in morning, but usually when restarting after driving. Does not, however, seem to be temperaturre dependant. Battery (relatively new) at 12.7V. When cranking, drops to around 11.2, so should be more than sufficient for ignition. When it starts, it fires up instantly. Runs well, good power and good fuel economy (30+ mpg). Has not failed when driving; just no start. I believe this is a key bit of information. I have connected it to a battery charger - no change, UNLESS I set the charger to "Start" (60 amps) at which setting I get instant joy. I have checked grounds (probably not all of them) and replaced the (I believe it is called) ignition module (apparently a coil). I'm kinda suspecting a weak contact within the ECU, though we looked at the CB and saw nothing obvious. Stephanie is ready to shoot either me or the car, since it has stranded her a couple times at lunch so that she has had to walk back to the office! 1995 Cabrio, all stock, 115K miles; 2.0L engine; Standard tranny; AC; generally good condition. Thanks for reading this far, Karl Wolz Phoenix, AZ |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.