Excessive oil consumption on these engines is usually the result of bad valve stem seal and/or worn guides. You need to confirm hot idle oil pressure with a gauge. May only be a bad sensor. Rarely do these oil pumps wear out but a sludged up or other dirty engine can clog the pump inlet screen. Usually these engine will run fine on 10w-40 unless you are getting things really hot form hi revs or high load. Also be careful that the oil level is not too high. Dennis
-----Original Message----- From: Vanagon Mailing List [mailto:vanagon@gerry.vanagon.com] On Behalf Of Bill MacLachlan Sent: Monday, October 19, 2009 6:26 PM To: vanagon@GERRY.VANAGON.COM Subject: oil pressure diagnosis. Hi all, I need a little bit of list wisdom/feedback here..... Just over a year ago I had a local shop put replaced my worn out I4 motor with a used one. The one they installed has been a lemon. Shop has just replaced rings and con rod bearings because the engine they put in was burning 0.5 litre of oil every 300 miles. Now when the motor is warmed up , the oil light's on at idle - wasn't before, but now it is. The only change has been the rings & bearings. Raise the revs 50 rpm and the oil light is off. Shop says oil pump's worn - low pressure at idle, but OK above idle - 60 lbs. @ 3000 rpm I wouldn't be surprisd if the oil pump is worn, but I'm also thinking (1) oil weight too thin- should be 20/50 not 10/40 (2) is this a symptom of worn main bearings too? It wouldn't surprise me. any thoughts welcome... it'd be good to hear your opinions.... Bill M 82 I4 GL |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.