Date: Thu, 12 Nov 2009 06:23:14 -0500
Reply-To: Dennis Haynes <d23haynes57@HOTMAIL.COM>
Sender: Vanagon Mailing List <vanagon@gerry.vanagon.com>
From: Dennis Haynes <d23haynes57@HOTMAIL.COM>
Subject: Re: Cost to R&R seal between tranny/differential
In-Reply-To: <4AFA0D36.4040107@gmail.com>
Content-Type: text/plain; charset="US-ASCII"
If the seals between the diff and auto section are leaking there should be
evidence of said leak by oil coming through the weep hole unless the wrong
seals were installed and installed wrong. Depending on the gear oil used it
is common for these differentials to cook the oil out due to heat and shear.
Audi had a massive problem with this back in the late 80's and had a recall
and upgraded to synthetic oil and added a sticker advising to check the diff
oil every 30K.
I would suggest oil analysis to see if in fact you have cross contamination.
The leak you described would also mean an overfilled auto section. I would
also upgrade both fluids to a good synthetic. Make sure the breather vents
are not covered/clogged with crud. Another source for internal leakage is
the governor seal. This is an easy fix with the tranny still installed.
Dennis
-----Original Message-----
From: Vanagon Mailing List [mailto:vanagon@gerry.vanagon.com] On Behalf Of
Rocket J Squirrel
Sent: Tuesday, November 10, 2009 8:03 PM
To: vanagon@GERRY.VANAGON.COM
Subject: Cost to R&R seal between tranny/differential
I took the van (1984, AT) to a local VW mechanic, Steve's Place, here in
Bend, Oregon, today to check into the "thunk" sound which I hear when I
take my foot off the gas. Last week it was suggested here that I might
check the motor and transmission mounts, CV joints, etc.
He poked and prodded and found nothing suspicious.
While he had it, I asked him to change the oil, check fluid levels.
Last year at this time he'd discovered that the differential was
effectively dry inside. The 17mm allen bolt was completely crusted over.
He suspected that it hadn't been checked in a long time. He topped it off
and it seemed fine, and seems fine now.
But today, he took another look and found that the level had dropped some.
There's no sign of a leak outside. He said that the transmission fluid
(auto tranny) looked discolored and proposed that there could be a leak in
the seal/gasket/whateveritis between the two.
A job like this is entirely outside my skills and tools and space to work
in.
I asked him to quote cost to R&R and he said $350-$400.
Whatcha all think?
--
Mike "Rocket J Squirrel" Elliott
84 Westfalia: Mellow Yellow ("The Electrical Banana")
74 Westrailia: (Ladybug Trailer company, San Juan Capistrano, Calif.)
Bend, OR
KG6RCR