sure, it's quite possible to get the distributor drive shaft/gear in incorrectly, ....resulting in # 1 spark plug position on the distributor cap being not where it belongs. I've seen that about 50 times on VW bugs. however........it sure is darn easy to tell which cylinder it's firing on . Since # 1 is the right forward cylinder, when the vales for its 'paired opposite' cylinder, # 3, the left forward cylinder.........when the valves for $ 3 are at 'point of balance' ( intake just closing, exhaust just starting to open, if turning the engine forward ) .....when 3 is like that, it's on # 1. it could happen in waterboxers too, but those cases are so seldomly spit that there's little opportunity for people to put the dist drive shaft in wrong. One important tip - always keep the distributor or something, like a wine cork, in the distributor hole in the block..... if you turn the engine with the distributor removed, there is some change of the shaft lifting up .......... and jamming even , due to two small metal rings on the bottom of it that can get cocked out of place, if that shaft lifts up. even splitting Type I cases, I leave the distributor in the left case half the whole time. But I never touch that stuff anymore now anyway. Scott ----- Original Message ----- From: "Allan Streib" <streib@CS.INDIANA.EDU> To: <vanagon@GERRY.VANAGON.COM> Sent: Friday, December 18, 2009 6:44 AM Subject: Re: stumped
> On Thu, 17 Dec 2009 19:20 -0800, "Scott Daniel - Turbovans" > <scottdaniel@TURBOVANS.COM> wrote: > >> perhaps a Tiico engine is differnt, but on all other VW engines, it's >> not possible to put the distributor in 180 out, but it's easy to check >> if that's suspected. > > Years ago I had an air cooled beetle with the distributer 180 degrees > out. Actually it was not the distributor but the drive shaft. During > a reassembly, the distributor drive shaft had been dropped in 180 > degrees out of phase. Everything ran great, but anyone who was > familiar with these engines would have been puzzled by which wires went > to which plugs. > > Allan > -- > 1991 Vanagon GL |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.