Oops, engine dies after prime? That's different. Check to make sure ECU is getting power and make sure grounds are clean and secure. Don't know much about the AFC system but I assume needs a good RPM and AFM signal to work. Just checked the Bentley and looks like the coil negative feeds the ECU an RPM signal, so check that the wire is intact and in good shape. Other than that the AFM may be bad, but I would think the engine would fire and idle even with a bad AFM.
_____ From: pdooley [mailto:psdooley@verizon.net] Sent: Sunday, January 31, 2010 4:33 PM To: 'zzyzx'; 'vanagon@GERRY.VANAGON.COM' Subject: RE: No current at FI injector plug
Looks like you have a "5th" injector, i.e. cold start injector. The CSI is probably triggered by a thermo time switch. I would check that circuit, the switch, and also verify injector function.
_____ From: Vanagon Mailing List [mailto:vanagon@gerry.vanagon.com] On Behalf Of zzyzx Sent: Sunday, January 31, 2010 4:09 PM To: vanagon@GERRY.VANAGON.COM Subject: No current at FI injector plug
1980 VW Vanagon Westy not getting fuel Photos of engine compartment here <http://www.zzyzx.org/1980_Vanagon_Kingman/index.htm> . Problem is engine starts fine if primed then quits once primer fuel is exhausted. It will not start without being primed. It seems the fuel injection system is not functioning properly. I've checked grounds and plugs for sure fit. Bentley outlines several tests which I've completed the following one failed. Bentley 1980-1983 pg. 24.6 suggests testing voltage supply at injector plug by quote 1. remove connector from injector. 2. connect test light on connector plug. 3. operate starter, test light must flicker. "If NO, refer to AFC Troubleshooting Guide (pg 7) catalog no. US 42-00-5955-1" This test failed to produce a flickering of test light. The fuel pump is delivering fuel to the ring. It seems the computer is not signaling to the injectors properly A google search of "US 42-00-5955-1" failed to yield useful results. Any ideas as to what component could have failed or where to find AFC Troubleshooting Guide (pg 7) catalog no. US 42-00-5955-1 Any guidance is appreciated Steve |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.