The Red Brick suffered the the falling tunnel syndrome, and while I did have the factory fix installed, I was not happy with it. The ends fractured and broke when they hit the floor, and that didn't get repaired with the factory fix - and I felt it should have been. In fact, my feeling was that if the tunnel fell - VW's faulty design - and the parts were damaged - again related to faulty design - that VW should have replaced the damaged and broken tunnel sections. It didn't happen. So, to deal with that issue, I made a couple of wide straps that wrap around the tunnel at the joints and then fasten to the ceiling frames. This closes the holes left by the broken pieces, gives it additional support, and after dressing the straps up a bit, it looks pretty good as well.. I haven't had to deal with the AC at the very back end of the van. John Rodgers Clayartist and Moldmaker 88'GL VW Bus Driver Chelsea, AL Http://www.moldhaus.com
Allan Streib wrote: > Jeff <vw.doka@GMAIL.COM> writes: > > >> I have repaired quite a few of these by riveting a thin metal plate in >> place of the cracked section. You need to be careful not to >> exasperate the cracking when attaching the plate. >> > > I did something similar. I drilled holes and used screws with "speed > nuts" (http://www.aaronspushnuts.com/tinnerman_spring_nuts.htm) instead > of rivets. I thought the spring metal of the speed nuts would help > accomodate temperature changes and expansion and contraction. > > For the sheet metal I used galvanized HVAC duct stock available at home > improvement stores. > > Allan > -- > 1991 Vanagon GL > > > |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.