On Fri, Aug 27, 2010 at 12:31 PM, Marius Strom <marstrom@microsoft.com> wrote: > I believe the cooling system is rated for a max of 15 PSI. > > I'm curious, though, under what general conditions are you likely to achieve max pressure in this sealed system? I can think of a few variables: > > 1) as temperature increases, pressure should increase as well (however, the overflow pressure cap is what limits this to 15 PSI) > 2) as water pump speed increases, there should be some increases in localized pressure (however, the overall system pressure should stay about the same - it's a sealed system, after all) > > What's the hive-mind say about this? If my thermostat housing drips a little bit at 15 PSI, but holds fine at 13 PSI, when am I likely to experience those last few bits of pressure? (Side note: I'm replacing my thermostat housing this weekend, but I assume the problem will just move to the next weakest link in the chain :) > A properly-sealed cooling system reaches approximately 15 PSI on every drive that is sufficiently long to heat the engine and coolant to full operating temperature. If it were not so, the overflow tank (behind license plate) would be unnecessary. The worst-case scenario is when the pressure-relief valve fails in the closed position and the cooling system sees much more than 15 PSI. You'll find out quickly which hose or clamp is the weakest link if this goes on for very long. I've never see a clamp fail, but seen plenty of hose ruptures. -- Michael Snow 1987 Syncro TiiCo 1982 Westfalia 1.9TD http://slowmachine82.blogspot.com/ |
Please note - During the past 17 years of operation, several gigabytes of
Vanagon mail messages have been archived. Searching the entire collection
will take up to five minutes to complete. Please be patient!
Return to the archives @ gerry.vanagon.com
The vanagon mailing list archives are copyright (c) 1994-2011, and may not be reproduced without the express written permission of the list administrators. Posting messages to this mailing list grants a license to the mailing list administrators to reproduce the message in a compilation, either printed or electronic. All compilations will be not-for-profit, with any excess proceeds going to the Vanagon mailing list.
Any profits from list compilations go exclusively towards the management and operation of the Vanagon mailing list and vanagon mailing list web site.